公司新聞

濟南水泥穩定碎石施工時要注重什么問題

來源：http://m.runbangpharm.com/ 日期：2022-03-25

　　水泥穩定碎石成活后遇雨不泥濘，表面堅實，是高級路面的理想基層材料。因此現在是越來越受歡迎，而且使用的范圍也是愈加廣闊。那么你知道水泥穩定碎石施工時要注重什么問題嗎？

　　Cement stable gravel alive after rain is not muddy, solid surface, is the ideal base material for advanced pavement. So now it is more and more popular, and the scope of use is more and more wide. So what problem should you notice when cement stabilizes macadam construction?

　　首先檢查底基，復核控制樁標高。水泥穩定碎石鋪裝前，應將底基層清理干凈，并灑適量水保持濕潤。

　　First check the base and check the elevation of the control pile. Before cement stabilized gravel paving, the base should be cleaned up, and sprinkle the right amount of water to keep wet.

　　混合采用集中工廠混合。工廠攪拌設備使用前，應對使用過的工廠攪拌設備及各計量系統進行調試，使混合料的含水量、骨料級配、水泥含量達到配比要求，使機器正常運行。輸出與所用鋪路的容量一致。

　　Mixing adopts centralized factory mixing. Before using the mixing equipment in the factory, the used mixing equipment and the measurement system should be debugged to make the water content, aggregate gradation and cement content of the mixture meet the proportion requirements and make the machine run normally. The output corresponds to the capacity of the pavement used.

　　攤鋪、碾壓時，攤鋪系數在3-5之間，施工中必須貫徹“寧高不低，不刮”的原則，所有施工項目應在水泥終凝時間前完成.滾壓后立即進行密實度測試，如果測試結果不符合標準，重新滾壓。

　　Paving, rolling, paving coefficient between 3-5, the construction must be carried out in the "rather high not low, not scraping" principle, all construction projects should be completed before the cement final setting time. Compactness test is carried out immediately after rolling. If the test result does not meet the standard, roll again.

　　一般情況下，濟南水泥穩定碎石作業完成24小時后，方可鋪設邊石。與砌筑的時間間隔不宜過長，否則混合料形成板坯后，板坯會變硬，增加施工難度，敲擊板容易破壞板坯的完整性。平板。

　　Under normal circumstances, Ji 'nan cement stable gravel operation is completed 24 hours after the laying of edge stone. The time interval with masonry should not be too long, otherwise, after the slab is formed by the mixture, the slab will harden, increasing the difficulty of construction, and knocking the slab is easy to destroy the integrity of the slab. The tablet.

　　維護時間不少于7天。在此期間，禁止車輛通行。灑水器每天灑水2至4次，以保持其濕潤。

　　The maintenance duration is no less than 7 days. During this period, no traffic is allowed. Sprinklers are sprayed 2 to 4 times a day to keep them moist.

　　由于水泥穩定碎石的施工時間短，同時要求一次性達到質量標準，否則成型的板體不容易修整。因此，要加強施工管理，提高施工機械化程度，形成規?；?biāo)準化的作業方式，輕松滿足水穩的施工要求。

　　Due to the short construction time of cement stabilized macadam, at the same time, it is required to meet the quality standard at one time, otherwise the plate body is not easy to repair. Therefore, it is necessary to strengthen construction management, improve the degree of construction mechanization, form a large-scale, standardized operation mode, easily meet the requirements of water stability construction.

　　濟南水泥穩定碎石施工時要注重什么問題？以上便是問題的相關解答了，如果您還有其他不明白的內容，歡迎點擊http://m.runbangpharm.com網址來咨詢！

上一條：濟南路面機械設備的軸承怎么合理更換？

下一條：使用濟南瀝青料時對天氣溫度有要求嗎？